V8매니아 로고
V8 Mania 자료실 커뮤니티 오픈마켓

정비/수리 노하우

차량 정비및수리할 때 얻었던 유용한 정보를 공유합니다.

(본 게시판에는 PDF화일을 올릴 수 있습니다.)

Home > 자료실 > 정비/수리 노하우

RPM 연동하여 엔진룸에 발생하는 기계적 소음 정비/수리 노하우 -카마로ss동호회

RPM 연동하여 엔진룸에 발생하는 기계적 소음

김지원(Dimitri)  |  조회수 :3243  |  2017-07-10 (14:49)

Ticking Rattle Or Buzz Noise Heard The Best In The Passenger Compartment - (Mar 20, 2017)

SubjectTicking Rattle Or Buzz Noise Heard The Best In The Passenger Compartment

BRAND:

MODEL:

MODEL YEAR:

VIN:

ENGINE:

TRANSMISSION:

FROM

TO

FROM

TO

Cadillac

CTS-V

2016 - 2017

All

All

6.2L LT4

All

Cadillac

Escalade

2015-2017

All

All

6.2L L86

All

Chevrolet

Camaro

2016-2017

All

All

6.2L LT1 LT4

All

Chevrolet

Corvette

2015 - 2017

All

All

6.2L LT1 LT4

All

Chevrolet

Silverado

2014-2017

All

All

4.3L 5.3L 6.2L L83 L86 LV3

All

Chevrolet

Suburban

2015-2017

All

All

5.3L L83

All

Chevrolet

Tahoe

2015-2017

All

All

5.3L L83

All

GMC

Sierra

2014-2017

All

All

4.3L 5.3L 6.2L L83 L86 LV3

All

GMC

Yukon Modules

2015-2017

All

All

5.3L 6.2L L83 L86

All

Supersession Statement

This PI was superseded to update Recommendation/Instructions. Please discard PIP5395A.

The following diagnosis might be helpful if the vehicle exhibits the symptom(s) described in this PI.

Condition/Concern

A customer concern of rattle or ticking noise that is louder inside the vehicle than outside.

The noise may be picked up at the back of the left valve cover.

The noise may also sound like a lifter tick

This may also be called a fuel line buzz or ringing noise. 

Recommendation/Instructions

Listen to the fuel line connection at the left side of the engine.  

If the noise is heard best at the fuel line (this sound will be real loud with a stethoscope).

The fuel feed line between the high pressure fuel pump and chassis fuel line could be the cause allowing high pressure pulsation back to the low side of the fuel system. There is not a good way to test the check valve, the line will need to be replaced. 

On  pickups and SUVs, a vibration in the fuel line at the fuel tank may also be observed.

Reevaluate the concern.

There  are two different fuel line types  that contain this check valve and vary by model. 

#PIP5395B: Ticking Rattle Or Buzz Noise Heard The Best In The Passenger Compartment - (Mar 20, 2017)

The line above is the fuel feed pipe for Corvette, truck and SUV.

This line connects the chassis fuel line to the high pressure fuel pump. 

#PIP5395B: Ticking Rattle Or Buzz Noise Heard The Best In The Passenger Compartment - (Mar 20, 2017)

#PIP5395B: Ticking Rattle Or Buzz Noise Heard The Best In The Passenger Compartment - (Mar 20, 2017)

These pictures above shows the chassis fuel feed pipe for the LT4 supercharged ZL1 Camaro. 

On LT1 Camaro and LT4 CTS-V this line would have a jumper line with quick disconnects at both ends. 

One end will connect to the chassis line and the other to the high pressure pump feed line. 

Warranty Information

LABOR OPERATION

DESCRIPTION

LABOR TIME

4026830

Fuel Feed Pipe Replacement

Use Published Labor Operation Time

Please follow this diagnostic or repair process thoroughly and complete each step. If the condition exhibited is resolved without completing every step, the remaining steps do not need to be performed.



증상 : 노킹은 확실히 아니고, RPM 연동해서 특정 상황 - 토크가 좀 걸려서 엔진에 진동이 생길만한 구간.

고단에 물려 있을때 1500~3000 rpm 사이의 가속상황. 등 에서 발생하는 미세한 태핏소음? 또는 체인소음? 등으로 들리는 노이즈



확실하진 않지만 의심되는 상황..


아직 수리하진 못했습니다.


추가로, 메쉬라인이 엔진위를 가로질러, 엔진쪽으로 꼽히는 부분.  그쪽도 다른차에 비해 뭔가 유격이 있는 느낌?ㅠㅠ


손가락으로 톡톡 치면 금속성 노이즈가 미세하게 느껴지는데. 이것또한 연료라인 맥동에 의해서 진동시 "차르르르르~" 하는


소음을 유발시킬수도 있을것 같습니다.


비슷한 사례 겪으신분 혹시 계신가요~?? 


모든 가능성을 소거한다는 개념으로,  부품수급이 된다면, 일단 두개로 나눠진 연료라인을 다 교체해 보고 싶네요 ㅋㅋ




  • 김도영(SunShine) | 2017-07-10 15:04
테스트 연료라인 빌려줄테니 테스트 해봐 ㅎㅎ
  •  김지원(Dimitri) | 2017-07-10 15:13
       헉... 설마 연료라인을 가지고 계실줄이야 ㅋㅋㅋ -0-b
감사합니다~!!!!!!
  •   김도영(SunShine) | 2017-07-10 15:26
        문제는 저거 제거하려면 특별한 툴이 필요한데....ㅎㅎ 있으려나?
  • 안세호(호세) | 2017-07-10 19:23
저는 주로 7단 걸려있을때 1000알피엠 정도에서 엑셀밟으면 탈탈탈 소음이 납니다.
  • 이지현(서울터보) | 2018-03-11 23:10
해결됬나요??저도그러네요ㅜㅜ
번호 제목 작성자 등록일 조회수
296 순정 개선 미션오일 교체 후 반년 주행후기    [1]
이태백(ltbs) I 2020-04-19 (13:07) I 조회: 3253
이태백(ltbs) 2020-04-19 (13:07) 3253
295 엔진오일은 모빌이 제일 많이 쓰시나요?  [1]
조우득(우드드드득) I 2020-04-19 (09:36) I 조회: 3250
조우득(우드드드득) 2020-04-19 (09:36) 3250
294 m2얼라이먼트 작업후기  [5]
김현중(마로마로마시마로) I 2020-03-24 (23:02) I 조회: 3248
김현중(마로마로마시마로) 2020-03-24 (23:02) 3248
293 미션 변속불가 수리 후기  [6]
곽동우(블비야가즈아) I 2020-03-20 (10:47) I 조회: 3253
곽동우(블비야가즈아) 2020-03-20 (10:47) 3253
292 8번 실린더 실화감지 정비내용 공유.  [16]
이형법(하얀늑대) I 2020-03-05 (10:52) I 조회: 3251
이형법(하얀늑대) 2020-03-05 (10:52) 3251
291 베터리 수명을 간접적으로 체크  [7]
김도영(SunShine) I 2020-03-03 (10:00) I 조회: 3250
김도영(SunShine) 2020-03-03 (10:00) 3250
290 원격시동 후 종종 보게되는 온도조절 창 먹통 증상  [3]
박기표(막스) I 2020-02-28 (16:14) I 조회: 3246
박기표(막스) 2020-02-28 (16:14) 3246
289 (엔진 경고등) 스로틀 위치센서 1 에러  [6]
최재훈(쵸이) I 2020-02-22 (18:59) I 조회: 3246
최재훈(쵸이) 2020-02-22 (18:59) 3246
288 조향장치 리콜 수리 받아 보신분 있나요?  [3]
최호준(깜블비SS) I 2020-02-03 (17:59) I 조회: 3249
최호준(깜블비SS) 2020-02-03 (17:59) 3249
287 NGK 점화플러그 가품 구별법  [7]
김지원(Dimitri) I 2020-01-07 (15:10) I 조회: 3248
김지원(Dimitri) 2020-01-07 (15:10) 3248
286 아래글을 해석하려다보니 해석해놓은게 있어서 퍼왔습니다.  [4]
김도영(SunShine) I 2019-12-31 (09:40) I 조회: 3247
김도영(SunShine) 2019-12-31 (09:40) 3247
285 GM 가변 알터에대한 이해.  [2]
김도영(SunShine) I 2019-12-31 (09:37) I 조회: 3251
김도영(SunShine) 2019-12-31 (09:37) 3251
284 LT5 풀리 시스템 소개  [1]
김도영(SunShine) I 2019-12-10 (10:16) I 조회: 3248
김도영(SunShine) 2019-12-10 (10:16) 3248
283 시트 하부 녹 점검 바랍니다  [1]
정곤(수도산) I 2019-11-07 (11:17) I 조회: 3249
정곤(수도산) 2019-11-07 (11:17) 3249
282 코르사 익스트림 쿼드팁 가변배기 관련  [2]
타이거(타이거) I 2019-10-20 (20:41) I 조회: 3248
타이거(타이거) 2019-10-20 (20:41) 3248
281 스마트키  [3]
지주성(Asdfgg) I 2019-10-12 (16:07) I 조회: 3243
지주성(Asdfgg) 2019-10-12 (16:07) 3243
280 8단 미션 떨림 대응용 개선 오일 파란색 ~  [5]
박기표(막스) I 2019-09-26 (15:42) I 조회: 3244
박기표(막스) 2019-09-26 (15:42) 3244
279 쉐보레 파업이래요..  [4]
박정찬(일산카마로) I 2019-09-20 (15:34) I 조회: 3246
박정찬(일산카마로) 2019-09-20 (15:34) 3246
278 동서울 직영 후기  [9]
하경목(드로) I 2019-09-19 (10:02) I 조회: 3244
하경목(드로) 2019-09-19 (10:02) 3244
277 GM 카마로 서비스 매뉴얼~!  [5]
김도영(SunShine) I 2019-09-04 (10:27) I 조회: 3250
김도영(SunShine) 2019-09-04 (10:27) 3250